I'm trying to communicate with TMC2209 (stepper drive) with an Arduino nano Every. I connected pin RX on pin D2 and TX on pin D3. I placed a 1K resistor between TX and RX. It seems I can write parameters (even I'm testing this deeply, I'm not so sure now..) but I'm not able to read nothing from driver.
Picture added 15/04/2021 related to datasheet of TMC2209
In my test, I tried with only one driver with address 0, means MS1_AD0 and MS2_AD1 connected to GND.
driver1.microsteps(MICROSTEPS);
SerialPort.print("Counter1=");
SerialPort.print(driver1.IFCNT());
SerialPort.print(", Status=");
SerialPort.println(driver1.DRV_STATUS());
I tried reading IFCNT and DRV_STATUS, always ZERO.
The initialization is done in this way:
#include <Wire.h>
#include <AG_AS5600.h>
#include <TMCStepper.h>
#include <AccelStepper.h>
#define ENCODER false
#define FEEDBACK_I2C true
#define GEARBOX 139 //51
#define MICROSTEPS 16
#define MIN_SPEED 20
#define MAX_SPEED 3000
double offsetHome = 77.0;
#ifdef ARDUINO_SAMD_VARIANT_COMPLIANCE
#define SerialPort SerialUSB
#define SYS_VOL 3.3
#else
#define SerialPort Serial
#define SYS_VOL 5
#endif
#define SW_RX 2 // TMC2208/TMC2224 SoftwareSerial receive pin
#define SW_TX 3 // TMC2208/TMC2224 SoftwareSerial transmit pin
#define EN_PIN 7 // Enable
#define DIR_PIN 8 // Direction
#define STEP_PIN 9 // Step
#define SERIAL_PORT Serial1 // TMC2208/TMC2224 HardwareSerial port
#define DRIVER_ADDRESS1 0b00 // TMC2209 Driver address according to MS1 and MS2
#define R_SENSE 0.11f // Match to your driver
// SilentStepStick series use 0.11
// UltiMachine Einsy and Archim2 boards use 0.2
// Panucatt BSD2660 uses 0.1
// Watterott TMC5160 uses 0.075
AG_AMS_5600 ams5600;
TMC2209Stepper driver1(SW_RX, SW_TX, R_SENSE, DRIVER_ADDRESS1);
AccelStepper stepper = AccelStepper(stepper.DRIVER, STEP_PIN, DIR_PIN);
String cmd = {};
void setup()
{
SerialPort.begin(115200);
Wire.begin();
Wire.setTimeout(10);
SerialPort.println(">>>>>>>>>> Program started <<<<<<<<<<");
pinMode(EN_PIN, OUTPUT);
pinMode(STEP_PIN, OUTPUT);
pinMode(DIR_PIN, OUTPUT);
digitalWrite(EN_PIN, HIGH); // Enable driver in hardware
// Enable one according to your setup
SPI.begin(); // SPI drivers
driver1.beginSerial(115200); // SW UART drivers
driver1.begin(); // SPI: Init CS pins and possible SW SPI pins
// UART: Init SW UART (if selected) with default 115200 baudrate
driver1.toff(5); // Enables driver in software
driver1.rms_current(2000); // Set stepper current to 600mA. The command is the same as command TMC2130.setCurrent(600, 0.11, 0.5);
driver1.microsteps(MICROSTEPS);
driver1.pwm_autoscale(true); // Needed for stealthChop
stepper.setMaxSpeed(degToSteps(500.0)); // steps/s
stepper.setAcceleration(degToSteps(1.0)); // steps/s^2
stepper.setEnablePin(EN_PIN);
stepper.setPinsInverted(false, false, true);
stepper.disableOutputs();
}
void loop()
{
unsigned long t0 = micros();
switch (step) {
case 0:
cmd = SerialPort.readString();
if (cmd.charAt(0)=='a' && cmd.charAt(1)=='=') {
acc = degToSteps(cmd.substring(2).toDouble());
SerialPort.print("Acceleration=");
SerialPort.println(acc);
cmd = "";
}
else if (cmd.charAt(0)=='d' && cmd.charAt(1)=='=') {
dec = cmd.substring(2).toInt();
SerialPort.print("Deceleration=");
SerialPort.println(dec);
cmd = "";
}
else if (cmd.charAt(0)=='c' && cmd.charAt(1)=='?') {
driver1.microsteps(MICROSTEPS);
driver2.microsteps(MICROSTEPS);
SerialPort.print("Counter1=");
SerialPort.print(driver1.IFCNT());
SerialPort.print(", Counter2=");
SerialPort.print(driver2.IFCNT());
SerialPort.print(", Status=");
SerialPort.println(driver1.DRV_STATUS());
cmd = "";
}
}
The hardware should be ok because the jumper for UART is configured as default on pin4.
Can someone help me to understand why?
Thanks Andrea